Users have to measure the voltage of the pack first and then the individual batteries. A brief test to bypass the OBC will confirm where the problem lies. If everything else is working and the Club Car DS golf cart is not moving forward, the area to check is the OBC. On the controller, the expert advice is to go for Alltrax controllers, preferably 400a. If due to any reason, you have a damaged controller that controls the functioning of the forward movement of the cart, you will face this situation of the cart moving in reverse but not forward. Checking individual batteries is very important to avoid such a situation.Ĭontroller: The design and functioning of the controller are similarly divided into forward and reverse movements of the golf cart. So, if one of the batteries were to fail then the movement in that direction will be curtailed. The cart moving only in the reverse and not in the forward position is peculiar and there are only a few areas that need to be checked.īatteries: Some golf cart batteries are designed and structured in such a way that in a pack containing six batteries, #1, #2 and #3 will service the forward movement of the cart and #4, #5, #6 take over when the cart is reversed. Replace the entire switch and the contacts if they are burnt. Keep the Run/Tow switch in the Tow positionĪ faulty Forward/Reverse switch can cause a Club Car golf cart to move in reverse but not forward.Raise the rear of the cart using a jack.Fuses (the fuse holder is next to the solenoid) -They could have accidentally blown out or got shortedĪ word of caution here whenever you work on the golf cart, follow certain standard procedures:.The F & R rocker switch (check if it has any corroded parts or if the wires are disconnected).The Run/Tow switch and the relevant connections.Wires – Just pull or shake them gently to ensure they are securely fastened.Some of the other things to be checked are: If it is hot, the issue could be due to the controller. The solenoid is one major component.Ĭheck if the resistor between the two big terminals on the solenoid is hot. In such cases, there are a few components in between the two that need to be checked. If the power from the battery pack is not reaching the motor, then the Club Car golf cart won’t move forward or reverse. Wrong handling can cause problems and the golf cart can get damaged.īe mindful of how the battery charge is measured.Ĭlub Car Precedent Won’t Move Forward or Reverse Each model may have a different component and you have to be careful while handling them. You must keep in mind that there are differences between the various models of golf carts. If you are not getting these readings, change your batteries. A 36V battery must show 38.3V on a full charge, while e a 48V battery reading must be 50.3V. You must check your battery pack thoroughly. Batteries in a pack of 3 or 4 batteries even if one fails, the required power won’t reach the motor. There are several reasons why your club car won’t move: Faulty parts such as the solenoid, OBC and wiring can also cause a golf cart to not move.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |